Calgary Jeep Association

« previous next »
Pages: [1]   Go Down

Author Topic: Rear axle noises  (Read 1674 times)

0 Members and 1 Guest are viewing this topic.

Offline NikF

  • Stocker
  • Posts: 8
Rear axle noises
« on: March 26, 2012, 03:47:13 PM »
So about a month ago I started hearing this kind of popping noise coming from the rear end of my 91 jeep wrangler yj. I pulled the rear tires off and found out the cause of the noise I think. There is about a quarter to half inch of movement horizontally in my rear axle. Like I can push and pull on the tire or hub and it moves back and forth. Does any one know what could cause that and how to fix it?
Logged

Offline morerpmfred

  • Talks waaay too much!
  • Posts: 1604
Re: Rear axle noises
« Reply #1 on: March 26, 2012, 04:15:30 PM »
No c clips on that year of yj?  Wheel bearings. If there is a groove in the axle shaft ,you may need those as well.
Logged

Offline TL-Iguana

  • Talks waaay too much!
  • Posts: 1117
  • XJ - The Official TJ Rescue Vehicle
Re: Rear axle noises
« Reply #2 on: March 26, 2012, 09:26:52 PM »
have you checked your rear u joints? My XJ did the same thing, but everything wass still within spec.....
Logged
I did a Google search for "hot trannies" but nothing came up about oil coolers  :o

Worrying too much about mpg with a Jeep is similar to worrying about your sister's virginity. An ok thing to be concerned about but...

'01 XJ on 35s, '11 Jk DD

Offline NikF

  • Stocker
  • Posts: 8
Re: Rear axle noises
« Reply #3 on: March 27, 2012, 01:15:02 PM »
Quote from: TL-Iguana on March 26, 2012, 09:26:52 PM
have you checked your rear u joints? My XJ did the same thing, but everything wass still within spec.....

So you had noises coming from the rear end whenever you went over bumps slowly? And it turned out to be the rear drive shaft u joints?
Logged

Offline TL-Iguana

  • Talks waaay too much!
  • Posts: 1117
  • XJ - The Official TJ Rescue Vehicle
Re: Rear axle noises
« Reply #4 on: March 27, 2012, 11:38:29 PM »
ujoints are cheap to replace, was only a suggestion. I can lift the back end of my xj up and the axles do have some lateral movement. Not entirely sure how much is too much, but they will move in and out to some degree :)
Logged
I did a Google search for "hot trannies" but nothing came up about oil coolers  :o

Worrying too much about mpg with a Jeep is similar to worrying about your sister's virginity. An ok thing to be concerned about but...

'01 XJ on 35s, '11 Jk DD

Offline Bnine

  • Talks waaay too much!
  • Posts: 2572
  • Sticky Fingers
Re: Rear axle noises
« Reply #5 on: March 28, 2012, 08:02:13 AM »
You need to be a bit more discriptive with your problem guy.

Telling these guys you hear "pop" from the arse end is like telling a doctor your bunghole hurts sometimes when you sneeze. How should he know whats wrong.

Anyways, what sound, what speed, is it rotational with the engine, with the clutch in, out, etc etc. The more clear you are, the easier it will be to help you.

Since you added that you hear it over slow bumps, I suggest you watch underneath as you have someone bounce on the bumper. Pay close attention to the shocks and their bushings.
Logged
My Mechanic Calgary
Mobile Auto Care
403-483-1083
[email protected]

Offline NikF

  • Stocker
  • Posts: 8
Re: Rear axle noises
« Reply #6 on: March 29, 2012, 12:13:39 AM »
Well I did have someone look underneath as I was jumping on the bumper. The shocks were just replaced and the springs and bushings look fine. A little wore but still good. There is no noise when I jump on the bumper. Only when I'm moving. And it's only when I go over bumps slowly. The noise doesn't get louder or faster with engine speed or depending on what gear I'm in. It's only when I'm going slow and going over bumps. And it seems to only happen if I go over bumps at an angle. If I go over a speed bump straight on I don't hear anything. If I go over it on an angle I can hear the noise again.
Logged

Offline Vinman

  • CJA Executive
  • Talks waaay too much!
  • Posts: 2237
Re: Rear axle noises
« Reply #7 on: March 29, 2012, 06:55:20 AM »
Quote from: NikF on March 29, 2012, 12:13:39 AM
And it seems to only happen if I go over bumps at an angle. If I go over a speed bump straight on I don't hear anything. If I go over it on an angle I can hear the noise again.

Because of this symptom, I would look at the swaybars links and bushings.

Vince
Logged
/l ,[____],
 l---L -OlllllllO-
 ()_)-()_)-o-)_)

Quote from: Bnine link=topic=25904.msg162940#msg162940      date=1341881306
. 
 Resident prick is my job and it took me ten years to earn that title

Offline fug

  • CJA Executive
  • Talks waaay too much!
  • Posts: 2345
  • Airdrie Pick n Pull
Re: Rear axle noises
« Reply #8 on: March 29, 2012, 02:49:15 PM »
You mention play when you yank on the tires.  Do you mean you can move the tire/wheel combo in and out?  or when you yank on a tire the whole axle shifts on the leaf spring?
Logged
Fug
TJ Rubicon

Offline NikF

  • Stocker
  • Posts: 8
Re: Rear axle noises
« Reply #9 on: March 31, 2012, 09:30:31 PM »
The tire/wheel combo moves in and out.
Logged

Offline cLAY

  • Talks waaay too much!
  • Posts: 2377
Re: Rear axle noises
« Reply #10 on: April 01, 2012, 10:50:20 AM »
Any sign of an oil leak? Oil stains down the tires, brakes soaked in oil, oil stains from the drums?
Logged
..

'93 ZJ, 5.2L, lifted/locked/36s..<gone>
'98 5.9er 4.10s,locked,LA,WJ knuckles
Pages: [1]   Go Up
« previous next »